Search results

Could I still bypass the fuel pump relay if the theft lite is on ? It's at my friend's house so I can't check it easily. One key also. No $ to spend on it as it way too many electrical issues, like windows. It also might be stuck in 4WD which is not keeping it from rolling. It's not a daily driver.

Hello again, been a while... The Exp has been working ok until I didn't run it for 6+ months. Cranks but won't run. Seems like I'm not hearing the fuel pump anymore. The THEFT light is blinking which seems to mean the fuel relay is not closed, ie, no fuel. Can I unplug a/the THEFT relay ? Will...

I figured as much, in that a battery acts like a capacitor. If I disconnect the + from the batt, will the Exp still run ? If it runs does this mean the alt is putting out some juice at least ?

Is it possible, w/o a ton of $, to make my 98 SOHC 4.0 better ? Ie, manual TC ?

Ok, this makes more sense every day :) A few days ago I was thinking that removing the juice would make the TC clutch disengage but that's not really posssible I don't think as then Ford would have to design it so the juice would have to be on all the time in 4WH. Seems like the...

Huh, I did not know that posi is really not locked up via gears, but still could slip. Does this mean, if i was so inclined, I could make most any old 70's car (I have a 74 LTD and a 76 LTD) act like it had Posi somehow ?

Good stuff to know. I didn't realize the engine would use so much. Didn't someone post that the only thing the batt does is start the car ? I'm pretty sure the Exp has a SOHC 4.0, but I am not 100% sure as the eng was replaced approx 5 years ago. I should back up. What happened is that after...

Yup, I will take the wire(s) off 1st, but it seems that may not help if the shift-motor is not spring loaded, so I will take the SM off.

Ok, so if posi and LS are the same thing, why did the 69 Camaro I have never slip, even in snow ? Only with that rear-end was I able to drive from VT to MA during the worst of the blizzard of 78. And why do most rear ends (I've always called them LS or limited traction) slip at the earliest hint...

No, the 4WH is not on, but with all the other GEM things that don't work 1/2 the time, I'm not surprised. I have read a lot of things in the past week or 2 re the Exp's 4wd system. Hopefully one last set of questions :) The 'brown wire' - does that actuate the "shift motor" which pulls or...

Ok, so for a newbie like me, plus I might have a slight case of info overload, 1st what I want to do is get it out of the 4WH I think it's stuck in. Can I do this by unplugging the wires ? And if that doesn't work ? Then do I take the shidt motor off and I can shoft it with pliars into 2WH ...

Thx. My Dad and I rebuilt a few alternators in the 70's, but no more it seems. I will stick to the JY or Advance, not sure yet. Is there any way to tell which model alternator I have ? 95A or 130A w/o taking it out ?

Ok, I read all these posts and those in other threads too... What would be the general opinion on MOST RELIABLE 4WD system, completely manual, no AWD, no sensors, no computers, etc ? Does the Explorer come in such a model ? 4Runner ? Range Rover ? Pathfinder ? I'm still not clear on another...

Great information, all. I am too old too admit just how old, but I have never given much thought to 4WD until now. Being an Engineer, means I will not rest ez until I know as much as I can handle... So, I have read all the replies and still have a few questions... It seems to me, corners are a...

Does the 96 arrangement make it more valuable ? If I do buy a different Exp, I would want it more simple than this 98 I have. I don't mind getting out and locking hubs either, i just want it to work, always. Do the early Exp's have locking hubs ?

Thx for the replies and info...lots of expertise here I am grateful for ! Yes, it is a 4.0 V6. 1st issue is to get it unlocked as it seems due to the noise that it is stuck in 4WH at the moment. What I will do 1st is to unplug the wires going to the TC. I suppose while I'm under there I could...

Thx for the replies and info...I just called Advance, and they have the 95A for $116 and the 130A for $160. WOW. Gone are the days of the $35 alternator (I'm over 60). Been a while since I had to buy one. As a side note, I drove it for 2 weeks, only a few nites, used the heat too, with no...

Shift motor ? I have read, that there is a cover with 3 screws on the TC that can be taken off to shift manually. Re the brown wire under the seat, that info is in the Brown Wire Fix thread, although, the pic of the seat is missing, not sure why. Re the GEM module, a year ago we went thru all...

This is an older post, but I will need to get back to it again ,aybe this Spring as the windows stopped working again, so, I need to update/fix the post as this is a 1998 EB Explorer, not 2000. I had erroneous info back then from the prev owner...

Thx. So you're saying getting to the BrownWire by removing the radio is easier than under the seat ? I have not done this before, defer to others and their experience, but do not know how to get the radio out, also it seems (to me the unexperienced :) it might be easier to remove the F seat...

I don't see a Useful Thread for this, so... My '98 EB isn't charging. I could swap batteries from one car to another once/week, and then let the other car (VW) charge the battery, swap back, etc...but this might be more of a PITA long term. What tells the alternator to charge ? Hopefully not the...

Curious, not that I will go out and do this today, or tomorrow, but, it seems to me the CV-axle-joints could be removed, for true 2WD operation. This might save some gas, and wear and tear, etc. It also seems to me, that due to the CV-axles having 2 CV joints each, one might be able to remove...

Hello (again) I have a thread going re my 98 EB Exp as I will eventually add the Brown Wire Fix as others have too it seems. But...this is a theoretical question re the transfer case, 4WH, and so on... I have read the 98 has a live axle, which afaik means that the F wheels turn the cv axles...

Thx (all) for the suggestions and info...I might try to dis/reconnect the connectors I have read abt under the hood, although I don't have much hope for that to fix things. I don't care if the Auto works, in fact, Ithink it's a really dumb idea on Ford's part. I'd rather it be switchable. In...

No dash lites re. to the 4wd work or are on. The windows don't work though. Sometimes the wipers don't work. Is the GEM computer the one behind the radio ? How much would another be ? I have read about the 'brown wire fix', and am wondering, rather than get another computer, why not add a...