rstumpy
New Member
- Joined
- February 9, 2007
- Messages
- 7
- Reaction score
- 0
- City, State
- Palouse, WA
- Year, Model & Trim Level
- '93 XLT
Picked up a '93 explorer XLT, auto, 4.0L v-6 for my wife the other day. It only has 92,000 miles and appeared to be extremely well-kept. Runs great, by the way.
After driving it a few hundred miles the cooling system began acting up. It would peg the temp guage now and then, but only for a second or two. When that happened the heater would only produce cold air, and it would go hot again when the temp dropped. I replaced the thermostat, temp sending unit, lower hose, and completely flushed the system, and carefully "burped" any air out of it. At that time I noticed that the freeze plug at the back of the passenger-side cylinder head and been popped-out and a rubber compression/expansion plug is now in it's place (holding fine and not leaking at all).
Sitting in front of the shop I ran it to operating temp tonight...everything was great...drove two miles down the road and the heater started producing cold air, the temp guage was at "M" in the "normal" range (it had been moving up and down in the normal range), and about that time, POOF-- the freeze plug on the block near the starter blew out. Obviously my cooling system is building pressure in the extreme?
There is NO visible oil in the water/coolant, and NO visible water/coolant in the oil. On the other hand, when the engine was warming up there seemed to be a lot of water vapor in the exhaust (the usual white dissipating clouds of exhaust, but more than I might expect on some rigs).
I'm fearing a cracked head or blown head gasket. BUT again, the fluids are not cross-contaminated and the thing runs absolutely great. None of the earlier symptoms where consistant either. The rad cap is a 13 lb. unit and functional. It overflowed the overflow tank two days ago. Clearly the pressure overcame the cap's ability today. Oh...the lower hose split three days ago, but it was an older hose...now I think it was the pressure issue.
I'd sure like some outside input before I start tearing things apart. We need the rig and can't afford to go looking for another just now.
Thanks much,
Rob
After driving it a few hundred miles the cooling system began acting up. It would peg the temp guage now and then, but only for a second or two. When that happened the heater would only produce cold air, and it would go hot again when the temp dropped. I replaced the thermostat, temp sending unit, lower hose, and completely flushed the system, and carefully "burped" any air out of it. At that time I noticed that the freeze plug at the back of the passenger-side cylinder head and been popped-out and a rubber compression/expansion plug is now in it's place (holding fine and not leaking at all).
Sitting in front of the shop I ran it to operating temp tonight...everything was great...drove two miles down the road and the heater started producing cold air, the temp guage was at "M" in the "normal" range (it had been moving up and down in the normal range), and about that time, POOF-- the freeze plug on the block near the starter blew out. Obviously my cooling system is building pressure in the extreme?
There is NO visible oil in the water/coolant, and NO visible water/coolant in the oil. On the other hand, when the engine was warming up there seemed to be a lot of water vapor in the exhaust (the usual white dissipating clouds of exhaust, but more than I might expect on some rigs).
I'm fearing a cracked head or blown head gasket. BUT again, the fluids are not cross-contaminated and the thing runs absolutely great. None of the earlier symptoms where consistant either. The rad cap is a 13 lb. unit and functional. It overflowed the overflow tank two days ago. Clearly the pressure overcame the cap's ability today. Oh...the lower hose split three days ago, but it was an older hose...now I think it was the pressure issue.
I'd sure like some outside input before I start tearing things apart. We need the rig and can't afford to go looking for another just now.
Thanks much,
Rob