Dismiss Notice



Register Today It's free! This box and some ads will disappear once registered!

Solved Fuse and relay locations--2nd generation power distribution box Layout-

Discussion in 'Stock 1995 - 2001 Explorers' started by Turdle, March 2, 2007.

^^Searches ExplorerForum.com^^





  1. Turdle

    Turdle Moderator Staff Member Moderator Elite Explorer

    Joined:
    June 16, 2003
    Messages:
    29,239
    Likes Received:
    883
    Trophy Points:
    143
    City, State:
    Humboldt, KS
    Year, Model & Trim Level:
    2000 Mounty
    I think this is a good sticky candidate--

    Fuses are listed here

    * = maxi fuse

    1*=50A I/P fuse panel
    2*=40A blower motor relay
    3*= 50A 4 wheel ABS module
    4*=20a Main light switch-Instrument cluster
    5*=50A Ignition switch, starter relay

    6*=20A Transfer case relay
    7*= NOT USED
    8*=20A Auto Ride Control Switch/on off switch
    9*=40A Auto Ride Control relay
    10*=30A PCM power relay

    mini fuses
    1=10A A/C relay
    2=20A Aux power point
    3= not used
    4=15A Fog lamps-Daytime lamps
    5=10A Air Bag diagnostic monitor
    6=10A Powertrain Control Module (PCM)
    7=30A 4WABS module
    8=30A PCM relay
    9=20A Fuel Pump relay and RAP module
    10= 15A Horn relay
    11=15A Park Lamp relay-Main Light Switch
    12=30A Main light switch--Multi Function switch
    13=15A Heated O2 sensors, EGR Vacuum Regulator, EVR solenoid,Camshaft position (CMP) Sensor,
    Cannister Vent Solenoid, A4LD Auto Transmission
    14=30A Generator-Voltage regulator


    Interior fuse panel (mini fuses)

    1=7.5A Power mirror switch
    2=7.5A Blower motor relay,PAD module,Air Bag diagnostic monitor
    3=7.5A Trailer tow connector
    4=10A Left headlamp
    5=10A Data link connector (DLC)
    6=7.5A Air bag diagnostic monitor, Blower motor relay, Passive deactivation Module (PAD)
    7=7.5A Trailer Tow connector
    8=10A Right headlamp, Daytime running lamps (DRL) module, Foglight relay
    9=7.5A Stop Lamp switch
    10= 7.5A Speed control-amplifier assembly,Brake pressure switch, Generic electronoc Module (GEM)
    Shift lock actuator, Blend door actuator, Main light switch, RABS resistor, A/C heater assembly
    Flasher
    11= 7.5A Instrument cluster, Main light switch, RABS resistor
    12= 10A Power window relay, Washer pump relay
    13= 20A Stop lamp switch, Brake pressure switch
    14= 20A Rear Anti Lock Brake system (RABS) module
    **10A 4WABS module**

    15=7.5A Instrument cluster
    16= 30A Windshield wiper Motor, Wiper Hi-lo relay, wiper run/park relay
    17=7.5A Cig lighter
    18=15A Drivers unlock relay-All unlock relay
    19=25A PCM power diode
    20=7.5A RAP module GEM module, Radio
    21=15A Flasher (hazard)
    22=20A Aux power socket
    23=15A Turn signals
    24===not used
    25= 7.5A GEM module, Instrument cluster
    26= 10A Battery saver relay, Electronic Shift relay, Interior lamp relay
    Power window relay,Electronic shift control module, transmission control
    27=15A Switch,DRL, Backup lamp switch, DTR sensor,Instrument illumination dimming control module
    Dome/map lamp, GEM,electronic shift,Interior lights,Glove box lamp and switch
    28=7.5A GEM module-Radio
    29= 15A Radio
    30=15A Park lamps, trailer Tow relay
    31===not used
    32=10A rear blower
    33=15A Headlamps, DRL module, Instrument cluster
    34=7.5A Rear integrated control panel, CD
    35=10A RABS test connector
    36=7.5A CD, rear integrated control panel, memory seat, Message center

    [​IMG]

    explorer power dist panel.jpg
     
    Last edited: January 1, 2018
    • Thanks Thanks x 4
    • Like Like x 2
    • Useful Useful x 1
  2. Support EF

    Elite Explorer 2 for 1 Sale! $20 for 2 years!

    Explorer Forum has probably saved you that much already, and will continue to save you money as you learn how to diagnose fix problems yourself and learn which modifications work without having to experiment on your own. Elite Explorer members see practically no ads, can add their own profile photo, upload photo attachments in all forums, and Media Gallery, create more private Conversations, and more. Join Today. Your support is greatly appreciated.



  3. ExplorerDMB

    ExplorerDMB Moderator/Technician Moderator Emeritus

    Joined:
    January 26, 2004
    Messages:
    6,202
    Likes Received:
    4
    Trophy Points:
    0
    City, State:
    Mechanicsville, Virginia
    Year, Model & Trim Level:
    2004 Acura TL
    Description of the fuses?

    -Drew
     
  4. CDW6212R

    CDW6212R Hauls the mail. Elite Explorer

    Joined:
    June 17, 2004
    Messages:
    19,615
    Media:
    5
    Albums:
    1
    Likes Received:
    1,125
    Trophy Points:
    143
    City, State:
    Knoxville, TN
    Year, Model & Trim Level:
    98 Limited AWD
    There are two boxes for 95-01's, my 99(narrower) is different than my 98 model.
     
  5. 410Fortune

    410Fortune MUD SEASON 2.0 Staff Member Moderator

    Joined:
    August 3, 2000
    Messages:
    24,249
    Likes Received:
    876
    Trophy Points:
    143
    City, State:
    NORTH IDAHO, 7B
    Year, Model & Trim Level:
    B2 Slightly Modified
    the later ones have the starter solenoid built into them dont they? The 96-95 has the fender mounted solenoid

    the 98 Mounty I parted out had a diff box so I think its 95-96 are same,. 97+ diff
     
  6. CDW6212R

    CDW6212R Hauls the mail. Elite Explorer

    Joined:
    June 17, 2004
    Messages:
    19,615
    Media:
    5
    Albums:
    1
    Likes Received:
    1,125
    Trophy Points:
    143
    City, State:
    Knoxville, TN
    Year, Model & Trim Level:
    98 Limited AWD
    The 99 starter solenoid is on my starter. The number of fuses and relays is similar, but my 98 harness had more odd relays elsewhere under hood.
     
  7. Turdle

    Turdle Moderator Staff Member Moderator Elite Explorer

    Joined:
    June 16, 2003
    Messages:
    29,239
    Likes Received:
    883
    Trophy Points:
    143
    City, State:
    Humboldt, KS
    Year, Model & Trim Level:
    2000 Mounty
    I edited it--
    This is from my 98---
     
  8. ExplorerDMB

    ExplorerDMB Moderator/Technician Moderator Emeritus

    Joined:
    January 26, 2004
    Messages:
    6,202
    Likes Received:
    4
    Trophy Points:
    0
    City, State:
    Mechanicsville, Virginia
    Year, Model & Trim Level:
    2004 Acura TL
    I put it in the List of Useful Threads :thumbsup:

    -Drew
     
  9. TR_TX

    TR_TX New Member

    Joined:
    August 3, 2007
    Messages:
    9
    Likes Received:
    0
    Trophy Points:
    0
    City, State:
    Texas
    Year, Model & Trim Level:
    1996
    Thanks sense blower motor works then I will need to begin checking out these do-hickies.
     
  10. BrooklynBay

    BrooklynBay Moderator & long time member. Staff Member Moderator Elite Explorer

    Joined:
    November 11, 2005
    Messages:
    53,805
    Likes Received:
    410
    Trophy Points:
    113
    City, State:
    Brooklyn, NY
    Year, Model & Trim Level:
    88 89 93 95 96 Aerostars
  11. Turdle

    Turdle Moderator Staff Member Moderator Elite Explorer

    Joined:
    June 16, 2003
    Messages:
    29,239
    Likes Received:
    883
    Trophy Points:
    143
    City, State:
    Humboldt, KS
    Year, Model & Trim Level:
    2000 Mounty
    I don't trust autozone's diagram's-if you look in the 98 explorer for example it mentions a WOT relay.
    there is no such thing as a WOT relay, in a 2nd gen explorer anyway. lol
     
  12. BrooklynBay

    BrooklynBay Moderator & long time member. Staff Member Moderator Elite Explorer

    Joined:
    November 11, 2005
    Messages:
    53,805
    Likes Received:
    410
    Trophy Points:
    113
    City, State:
    Brooklyn, NY
    Year, Model & Trim Level:
    88 89 93 95 96 Aerostars
  13. Turdle

    Turdle Moderator Staff Member Moderator Elite Explorer

    Joined:
    June 16, 2003
    Messages:
    29,239
    Likes Received:
    883
    Trophy Points:
    143
    City, State:
    Humboldt, KS
    Year, Model & Trim Level:
    2000 Mounty
    If you guys with 95,96,97,99,00,and 01 owners manuals could please scan and post the same in here, or email them to me-I'd sure appreciate it:thumbsup:
    Not to sound picky,(I am) but I don't want anything from an on line source here-I don't really trust them.

    There are differences from year to year-and I think this would be very helpful.

    Thanks:D
     
  14. Turdle

    Turdle Moderator Staff Member Moderator Elite Explorer

    Joined:
    June 16, 2003
    Messages:
    29,239
    Likes Received:
    883
    Trophy Points:
    143
    City, State:
    Humboldt, KS
    Year, Model & Trim Level:
    2000 Mounty
    naw
    thanks
    \I'll delete these posts also-trying to keep this info tidy:D
     
  15. juggaloscorpio

    juggaloscorpio Member

    Joined:
    June 10, 2007
    Messages:
    83
    Likes Received:
    0
    Trophy Points:
    0
    City, State:
    Sherman, Texas
    Year, Model & Trim Level:
    1995 XLT
    can someone scan in a pic and add description of the power dist. box and interior fuse box for 95 and 96 xlt thanks ahead of time
     
    • Thanks Thanks x 1
  16. jwrezz

    jwrezz Elite Snow Shoveler Elite Explorer

    Joined:
    March 23, 1999
    Messages:
    1,119
    Likes Received:
    6
    Trophy Points:
    48
    City, State:
    Parsippany, NJ
    Year, Model & Trim Level:
    1996 XLT
    Here ya go:

    [​IMG]

    [​IMG]

    [​IMG]
     
    • Like Like x 1
  17. redlined_man

    redlined_man New Member

    Joined:
    May 2, 2009
    Messages:
    2
    Likes Received:
    0
    Trophy Points:
    0
    City, State:
    Southwest Wisconsin
    Year, Model & Trim Level:
    1999 XLT
    I have read this post and thought I figured out my problem on my 1999 Explorer. However, when I plug my trailer lights into it my 3rd brake light comes on right away when I have the head lights on, and I have no left side blinkers or brake lights on my trailer but both tail lights work. Does anyone know why this could be happening? Any quick info would be great since I need to use my trailer in about 12 hours. Thanks in advance.
     
  18. jwrezz

    jwrezz Elite Snow Shoveler Elite Explorer

    Joined:
    March 23, 1999
    Messages:
    1,119
    Likes Received:
    6
    Trophy Points:
    48
    City, State:
    Parsippany, NJ
    Year, Model & Trim Level:
    1996 XLT
    Do the explorer's lites work fine when the trailer harness is NOT plugged in? If so, it sounds like something is shorting in the harness only. Or maybe even a mismatched harness? Seems like the tail lites are shorting to your 3rd break lite some where in there, and break/blinkers are not even reaching the trailer. Do the explorers signals/break lites work w/ the harness plugged in and headlamps off? This just seems like a bad harness, or improper harness installation.
     
  19. redlined_man

    redlined_man New Member

    Joined:
    May 2, 2009
    Messages:
    2
    Likes Received:
    0
    Trophy Points:
    0
    City, State:
    Southwest Wisconsin
    Year, Model & Trim Level:
    1999 XLT
    Thanks for the reply jwrezz. It was really odd on how i got it fixed, I had to replace the #7 fuse, which was blown, and that got me to the problems that I explained in the above post. I then took the wiring off the tow dolly and started over, since everything seemed to work great at the pigtail on the Explorer. I found some bad spots in the wiring on the dolly so I replaced that and still had no brake lights or turn signals on the right side with the headlights on. Just on a thought I replaced the right 1157 bulb on my dolly and now everything works great. There was also a bad ground so I got a better ground and everything is good. Thanks again for the reply.
     
  20. ivrb

    ivrb Member

    Joined:
    July 31, 2006
    Messages:
    81
    Likes Received:
    0
    Trophy Points:
    0
    City, State:
    southern cal
    Year, Model & Trim Level:
    2000 xls
    other fuse box

    my 2000 has another fuse box just below battery, What are they for?



     
  21. jjfbugs09@att.ne

    jjfbugs09@att.ne New Member

    Joined:
    March 13, 2010
    Messages:
    1
    Likes Received:
    0
    Trophy Points:
    0
    Year, Model & Trim Level:
    2007 xlt
    i need a ford explorer fuse box print-out 2007 yr. 4.0 engine
     

Share This Page







We Support Our Troops!