4405

Had some issues with my rig. Pulled the transfer case and found this along with some other issues. First question: Is this still a viable gear? Second question: Where do I get a new Hi Low collar, or range shifter gear? Last question: Where do I purchase the Omega Shift Fork? Thank You.

Hi, So after diagnosing that my transfer case was indeed at fault i want to replace it. budget being an issue for me at the moment, im opting for a used one. since im buying it private party i want to make sure what i get matches up, but im running past my normal range of knowledge. My TC tag...

I have a '97 UN Explorer 5 spd manual, A4WD. Borg Warner 4405 when in 4 hi or 4 lo I still only get wheelspin at the rear wheels. I have jacked the rear of the car up leaving the front wheels on the ground and chocked, if I let the clutch out in first gear in 4WD low I can feel the car try to...

I just swapped the 4405 transfer case in my 97 4.0 with one out of a 98. How can I find out what chain is in the 98. I swapped the back half of my 97 onto the 98 to get VSS output. Everything works fine except that there is a lot of slack in the chain and I am getting a loud clunk or pop when I...

I've already got everything out and ready to stuff the 1354 in everything is wired up but the older T-case has a 2 wire speed sensor and just one. The 4405 appears to have 2 sensors that are 3 wire. The old t-case had a gear/cable that maybe ran the speedo at one point... so what can i do to...

I have some questions on transfer cases and swapping them. I have 2 Explorers (or 1 1/2 might be more accurate). Both are 1997 XLT's, but mine is the pushrod 6 with a manual transmission, and my wife's is (was) a SOHC 6 with a slushbox, er I mean automatic. My wife's, with 210,000 miles of...

Looking for some input from the vast wealth of knowledge here on the forum. To give you a brief run down, I am swapping out my 4405 c-trac case for a 1354. The 1354 I have is an electric version and converting it to manual is a little pricey. This being said I am building a controller for the...

i have a 1995 ford explorer I was under their last night and found out i have the 4405 t-case. I unfortunately do not want to have this t-case because i have a dana 30 and i wound like a part time transfer case instead of a full time. my question is, wich transfer case do i swap in and what...

I am in the process of converting the transfer case in my 96 from the BW4405 electric to the BW1354 manual and I can NOT seem to find the linkage in any of my local salvage yards. If anyone can point me in the right direction towards finding the linkage I will be eternally greatful. I had a...

Borg Warner 4405 Exploded Diagram