blend door actuator

My girlfriend has a 2008 Mercury Mountaineer. Manual climate controls with one zone up front and also manual rear controls. About a year ago, her car randomly was only able to run A/C, motor speed was adjustable, and front vents only. Her stepfather went in to try to figure it out, found out...

Hello. My plastic mode door lever is broken (it is pretty common from what I've seen). I selected different positions on the control panel for defrost, defrost/floor to see where I can position the broken lever until I fix it, but the actuator arm only went in all the way, and out all the way...

My 2003 Explorer Sport XLT has a failed blend door actuator, stuck on full hot. The mechanic I usually use wants to charge clsoe to $1000 because "you have to disassemble the entire dash". I do not believe this is true and will be talking to some other mechanics. I've seen videos about how to...

My 2003 Explorer Sport XLT has a failed blend door actuator, stuck on full hot. The mechanic I usually use wants to charge clsoe to $1000 because "you have to disassemble the entire dash". I do not believe this is true and will be talking to some other mechanics. I've seen videos about how to...

1997 Ford Explorer Eddie Bauer 4X4. So I've had this car for about a month, it has only one previous owner, impeccable service history and only 90,000 miles on it. Recently, the power steering went out and the auto shop repaired the pump, pulley, pressure line, fluid and freight parts. When I...

Hey folks. My 95 Explorer has well running regular AC, but just this past week when I set it to MAX, it changes over and blows fine for a few seconds and then slowly something closes and no more air of any kind blows. You can feel something slowly closing as the air goes from blowing hard to...

Hi, I replaced my blend door actuator in my 2016 sport a couple months back. It worked, but the actuator seemed to ignore the limits of the damper and kept trying to open or close further, eventually causing a gear tooth to break in the actuator. How do I reset the system after replacing the...

I have posted before about my problems with my 1997 Eddie Bauer Explorer. So the blend door actuator broke off and I got a new one and installed it., eazy pezy.....not. It still only blows hot air. Since I have done the heater treater repair to the blend door previously I can take the bottom of...

Hello everyone! I'm new to this forum so please forgive me if I'm posting in the wrong area. Anyways, the issue I'm having on my 2004 Explorer XLT 4.6 V8 is that when I turn my defrost control to either the floor, defrost/floor, or just defrost, NOTHING changes. I'm getting warm and cold air...

I'm sure there's probably been a lot of posts that talked about the Blend door actuator but I never got the answer. So, guess this will be another one. My question: why is there no power going to the blend door actuator in my 2001 Ford Explorer even if the fuses are good? Please help! Spent...