Foxracin's 1991 Exploder | Page 29 | Ford Explorer Forums - Serious Explorations

  • Register Today It's free!

Foxracin's 1991 Exploder

Real Name: Trevor
Year : 1991
Model: Explorer
State: North Carolina
City: Mount Holly



Just picked up this Exploder last week. Its not in the best of shape but overall its decent. The motor runs great and the body has very few dents and dings.

When I got it the trans was out like every other a4ld. I am a 5 speed guy myself and was planning to convert to 5 speed anyway.

First thing and did is check the fluid in the trans. Nice and red, full, and doesnt smell burnt. Pulled one of the lines at the radiator and fired it up and no fliud. Nothing at all. Pulled the pressure plug in the side of the trans and fired it up to make sure the lines were not stopped up somewhere and still nothing so I knew something wasnt right with the pump.

Got it home and put it on some jack stands and started tearing out the trans.
explorer2.jpg

explorer.jpg


Got the trans out and pulled the torque converter out and found some scaring on the snout. Thats not supposed to be like that. lol
broketrans3.jpg


Pulled the bellhousing off then the pump from the bellhousing and theres the problem. One of the pump gears cracked and spread the teeth apart and locked up and spun on the torque converter.
broketrans.jpg

broketrans2.jpg


Oh well time to throw it in the scrap pile. Dont want to spend the money on it again not even know if the rest of the trans is good and for it to just break again. I figured I could swap in a 5 speed for not much more then fixing the a4ld.

Figured I would mess with the inside a little while I try to find a trans.

Put in a Sony headunit. Ran new speaker wires and used the internal amp after 2 stock amps were not right. Soldered all the connections and ran new speaker wire and its good as new.
explorer7.jpg


Put it in a Midland CB I had laying around.
explorer6.jpg


Overall shot of the interior.
explorer4.jpg


Then I figured I would ride over the the Pull-A-Part to see if I could run across anything. Sure enough ran across a 1992 5 speed Exploder. But somebody already robbed the trans and starter. Figured I would go ahead and get what I could off it. Got the computer, Manual trans wiring harness, pedals, and Master cylinder(when they got the trans they cut the line so it wasnt useable). Still had the flywheel, clutch/pressure plate still on it too but I didnt have the money for it right then.

So I came home and started swapping out some stuff.

Manual trans wiring harness.
explorer9.jpg


Swapped computers and moved it to behind the glove compartment to get it a little higher.
explorer5.jpg


Swapped the pedals. I left the pedal assembly in and just changed out the brake pedal and put the clutch pedal on. It was aggravating but definitely beats pulling the dash out to change the entire assembly.
explorer8.jpg


Went back the next day to Pull-A-Part to get the clutch and flywheel and all that good stuff crawled under it and somebody done took the clutch and pressure plate. So I missed out on that. Went ahead and pulled the flywheel off though. It looked fairly new.
explorer10.jpg


Pile of junk parts I have pulled off so far. lol It keeps getting bigger.
explorer3.jpg


Thats where I am at so far. Need to scrounge up some money to get me a trans and a few other pieces and I should be set.

For now I will probably just do a body lift and coil spacers and shackles for now with some 33's or 34's after I get it on the road.

Then save up for the d44 SAS down the road.

Ill keep this thread updated as I get some more work done.
 



Join the Elite Explorers for $20 each year.
Elite Explorer members see no advertisements, no banner ads, no double underlined links,.
Add an avatar, upload photo attachments, and more!
.








Join the Elite Explorers for $20 each year.
Elite Explorer members see no advertisements, no banner ads, no double underlined links,.
Add an avatar, upload photo attachments, and more!
.





Just got finished putting in a new cb. Had to slightly modify the dash a little bit. lol

Stuff that I ripped out of the dash.

IMAG0252.jpg


It fits in the hole now.

IMAG0247.jpg

IMAG0248.jpg

IMAG0251.jpg


New antenna mount and coax is supposed to be here today so I can get the antenna back on and be back in business.
 


















I like it. I only gave like $100 for it used so it was well worth it. A lot firmer feeling and whole lot less throw.

Dang you must've been in the right place at the right time for that deal.... they retail for $230.

If you ever stumble upon another one for that kind price, let me know.
 






What degree of C-bushing did you end up using on this swap?
 






Cb

What model cb is that. Its awesome looking and your ride is one super ride and I have enjoyed your post. Whats next.:usa:



Just got finished putting in a new cb. Had to slightly modify the dash a little bit. lol

Stuff that I ripped out of the dash.

IMAG0252.jpg


It fits in the hole now.

IMAG0247.jpg

IMAG0248.jpg

IMAG0251.jpg


New antenna mount and coax is supposed to be here today so I can get the antenna back on and be back in business.
 






Back
Top